Asia – Mediterranean via Suez
Mediterranean services are the ones most likely to use Suez again (57% in September 2026), which puts the cargo back through Bab el-Mandeb, rated a SUBSTANTIAL threat.
Europe · sea freight from Shenzhen
Shipping from Shenzhen to Naples
Shenzhen to Naples
South China Sea · Malacca Strait · Indian Ocean · Bab-el-Mandeb · Suez Canal · Aegean Sea · Ionian Sea · Tyrrhenian Sea
- ShenzhenChina origin
- South China Sea
- Malacca Strait
- Indian Ocean
- Bab-el-Mandeb
- Suez Canal
- Aegean Sea
- Ionian Sea
- Tyrrhenian Sea
- NaplesItaly
This route runs from factories around the Pearl River Delta through Yantian or Shekou, then follows a Suez corridor that Mediterranean services are using again more than any other Asia–Europe lane; at the far end is the port of Naples.
The Italian side adds the registropile.it registration to the EU battery rules. The 5 points below are particular to this lane; each comes with what we do and the paperwork it touches.
What we need to start
- Yantian / Shekou export
- Typhoon season Jun–Oct
- Consignee EORI
- EU declaration of conformity
- Registro pile number
Route profile
The Shenzhen → Naples route in brief
Italy
Registration with the Chambers of Commerce battery register (through an Italian representative for foreign producers), the number on every commercial document, and the EU-wide CE and label duties.
Where this route gets difficult
Where Shenzhen → Naples shipments get held up: 5 points
They run from the Shenzhen terminal through the voyage to Naples and the Italy import file.
- Origin port
Factory stuffing in Dongguan, loading at Yantian: avoid a second opening
Much Shenzhen battery export is stuffed inland and trucked to the terminal. In May 2026 Yantian MSA and Dongguan MSA ran a cross-regional 'one-box' pilot: four battery containers were inspected jointly at the Dongguan factory and loaded at Yantian without being opened again. It shows that the inspection record made at the factory is what matters at the terminal.
What Anxin does: We ask at booking whether your factory and the terminal's MSA office can use the one-box arrangement, and we have stuffing photos, the packing certificate and the DG declaration match exactly, so the container is not held for re-inspection.
- Sea corridor
If the service goes round Africa instead
The 43% of Mediterranean services not using the Red Sea sail round the Cape of Good Hope, then back through Gibraltar. SAMSA estimates about 200 of the 576 containers lost at sea in 2024 went overboard near the Cape, 35% of the year's total.
What Anxin does: On Cape sailings we apply the CINS blocking and bracing checks strictly on stuffing photos before sealing.
- Import country
CE marking and a declaration of conformity in the right language
Since 18 August 2024 a battery sold in the EU needs the CE marking and an EU declaration of conformity from its manufacturer. The declaration has to be available in the language Italy requires, and the importer is the one who must check both before the goods are released for sale.
What Anxin does: We ask the manufacturer in China for the declaration of conformity and a photo of the CE marking on the battery or its packaging before loading, and pass them to the Italy importer. We check that the documents exist and match the goods; we do not assess conformity.
- Import country
Battery label from August 2026, QR code from February 2027
The Battery Regulation's general information label applies from 18 August 2026 (or 18 months after the label implementing act, if later), and every battery needs a QR code from 18 February 2027, linked to a battery passport for EV, LMT and industrial batteries above 2 kWh. Where the battery is too small, both go on the packaging and accompanying documents.
What Anxin does: Before booking we ask the Italy importer to confirm the battery category and whether the label and QR-code elements are already on the goods, and compare carton photos with that answer.
- Import country
Supply-chain due diligence moved to August 2027
The Battery Regulation's due diligence obligations on cobalt, lithium, nickel and natural graphite were postponed by Regulation (EU) 2025/1561 and now apply from 18 August 2027, with Commission guidelines due by 26 July 2026. Buyers in Italy are already asking suppliers for the supply-chain data they will need.
What Anxin does: We pass the Italy buyer's due diligence questions to the manufacturer and keep their answers with the shipment file; the policy itself remains the producer's responsibility.
Documents & compliance
What to have ready: Shenzhen to Naples
These documents come from the shipper, the manufacturer and the importer. Anxin checks them against each other; it does not issue test reports, safety data sheets or import certificates.
At the Shenzhen end
- Confirmation from the carrier of the DG cut-off at Yantian or Shekou, rechecked in typhoon weeks
- Container packing certificate signed by a certified packing inspector after supervised stuffing
- Transport-condition classification report where applicable
- Load plan showing even weight distribution (no more than 60% of the cargo weight in either half of the container length)
- Register number to appear on the commercial invoice
Carrier and voyage
- Routing (Red Sea or Cape) and any war-risk surcharge stated on the booking
- Lithium battery mark (SP188 cargo) or class 9 labels and placards
- Condition statement: new, used, damaged/defective (SP376) or for recycling (SP377)
For the importer in Italy
- Label and QR-code status against the August 2026 and February 2027 dates
- Haulier in Italy briefed with UN number, class 9 and tunnel code (E) for the road leg
- Italian battery register number of the producer or its representative
Before you book
Send the file once, complete
Most delays on this route start with a document that exists but does not match: a UN number, a model name or a package count that differs between the Shenzhen filings, the carrier booking and the Italy import file. We check the three against each other before the booking is confirmed.
Carriers we book with
Our booking panel; availability on this lane and acceptance of the declared UN numbers are confirmed for each booking. It does not mean that a listed carrier runs a direct service on this route. Carrier choice depends on the trade lane, cargo classification and each carrier's dangerous-goods acceptance at booking. The final carrier is confirmed on the booking.
Risk & mitigation
Risks on this route and who deals with them
| Risk | Where | Mitigation | Who acts |
|---|---|---|---|
| Container reopened at the terminal because records do not match | Factory → Yantian | Photos, packing certificate and DG declaration cross-checked before trucking | Anxin |
| Heavy weather off South Africa on a Cape sailing | Cape of Good Hope | CINS stuffing checks | Packing site, checked by Anxin |
| Declaration of conformity missing or not in the required language | Importer in Italy | Declaration and CE photo collected before loading | Manufacturer / importer |
| Stock shipped without the label due from August 2026 | Importer in Italy | Label status confirmed before booking | Manufacturer / importer |
Questions
Common questions on the Shenzhen → Naples route
The CE marking on the battery and the manufacturer's EU declaration of conformity, which must be available in the language Italy requires. Both have applied since 18 August 2024.
Often: in September 2026, 57% of Asia–Mediterranean services used the Red Sea routing. Bab el-Mandeb was rated a SUBSTANTIAL threat by the JMIC on 24 September 2026, so we confirm each service's routing before booking.
Yes, provided a certified packing inspector supervises the stuffing and signs the container packing certificate. Since May 2026 Yantian and Dongguan MSA have also piloted joint factory inspection so the container can be loaded at Yantian without reopening; we check whether your shipment can use it.
References
Official sources for this page
- Registro dei produttori di pile ed accumulatori (Camera di Commercio di Venezia Rovigo, Ufficio Unico Ambiente)
- Regulation (EU) 2023/1542 on batteries and waste batteries (ELI) (EUR-Lex / Publications Office of the EU)
- Regulation (EU) 2025/1561 amending Regulation (EU) 2023/1542 as regards due diligence obligations (EUR-Lex / Publications Office of the EU)
- Inland transport of dangerous goods (summary of Directive 2008/68/EC) (EUR-Lex)
- JMIC Update 099 to Advisory Note (Joint Maritime Information Center (via UKMTO))
- Yantian MSA runs 'one-box' model for lithium battery sea exports (Chinese), 8 May 2026 (Shenzhen Development and Reform Commission (source: Shenzhen MSA))
- Forecasting yearly number of tropical cyclones affecting Hong Kong (tropical cyclone season June–October, most active July–September) (Hong Kong Observatory)
Next step
From enquiry to import
- 1EnquiryCargo, origin, destination
- 2Documents checkUN 38.3, SDS, packing
- 3BookingAfter carrier acceptance
- 4HandoverAt Shenzhen
- 5ImportClearance at Naples
Prefer chat? Chat on WhatsApp (+86 151 4514 5178)
After you send it
We check carrier acceptance for Shenzhen → Naples before any booking, and ask for missing battery documents first.
All destinations from Shenzhen · Italy ports
Need Shenzhen → Naples reviewed?
Share the cargo facts; we review the route in writing.
Request a Quote